Thursday, December 12, 2013
(Continued from page 1)
‘CLASSIC, OLD LIFT STUFF’
Ski safety expert Richard Penniman said many of the issues noted in the last two state inspection reports of Sugarloaf’s lifts are indicative of older equipment.
• He pointed specifically to metal fatigue, corrosion and electrical problems – “classic, old lift stuff,” he said.
• He said some of the issues might be expected in the fall, when the state inspections were done, because lifts might get less attention during the summer months, and mice, gophers or other small animals can wreak havoc on wiring.
• He added that old lifts are like old cars: they tend to develop more problems during the cold winter months, even if they recently passed inspections.
• Spokesman Ethan Austin said Sugarloaf’s maintenance department is busy all year. “We have a very skilled lift maintenance staff employed year round and they spend the entire summer maintaining and upgrading lifts.”
SKI LIFT MANUFACTURER HISTORY
The Spillway East chairlift was manufactured by Borvig Ski Lifts and installed in 1975.
The manufacturer made lifts from 1962 to 1991 and closed in 1993.
In 1996, Hagen Schulz, son of Borvig Ski Lifts founder Gary Schulz, founded Partek Ski Lifts. Schulz used a lot of Borvig’s designs when first starting Partek. The New York-based company installed 24 lifts in North America before the company was purchased, along with all of Borvig’s lift patents, by Austrian ropeway manufacturer Doppelmayr CTEC in 2005.
As of December 2009, Doppelmayr/Garaventa Group has designed and overseen more than 14,100 installations worldwide. The company is a world leader in the ropeway sector. Doppelmayr USA, Inc. is based in Salt Lake City.
Sugarloaf now works with Par-Tech, a company based in New York, regarding Spillway East.
Sources: www.skilifts.org, www.doppelmayr.com, Sugarloaf
In cases of misalignments, ski resorts can unload passengers by running the lift slowly, or stop the lift and lower skiers by rope.
"They were trying to run people off the lift . . . But if the lift is not safe to run, it is not safe to run," said Penniman. "If they went, 'Oh my God this is about to fail,' and let it run anyway, they made a mistake."
Chairlifts do have safety measures designed to avert derailment. For instance, so-called deropement switches, also called "brittle bars," are supposed to stop the lift if the cable derails. And cable catchers are supposed to keep a derailed cable from falling. On Tuesday, the cable catcher didn't work.
"Part of the investigation will be to see why those didn't stop the lift from falling," Austin said.
A similar chairlift derailment happened at Whiteface Mountain Ski Center in upstate New York the day after the accident at Sugarloaf, but a cable catcher stopped the cable from falling.
Inspectors from the Maine Board of Elevator and Tramway Safety suspect high winds contributed to the accident, according to a Sugarloaf news release. But they have not ruled out other reasons for the failure of the 35-year-old lift.
According to Mike Cempa, a meteorologist at the National Weather Service, a weather balloon launched from Gray at 7 a.m. on the morning of the accident reported winds at 45 to 50 mph at between 2,000 and 4,000 feet, with higher gusts. Wind speeds declined later that morning, though gusts continued.
Penniman said the lift that failed, a double-chair model made by now-defunct Borvig Ski Lifts, is lighter than newer models and therefore generally has lower wind tolerances.
He said 40 mph winds may, depending on the wind direction, be near the lift's safe limit.
And he said gusty winds are more likely to cause problems than steady winds, because they can cause chairs to swing and knock against the towers.
Austin, the Sugarloaf spokesman, said "there is no specific wind speed which dictates when a lift must shut down."
The decision to stop a lift, he said, is based on a variety of factors, including wind speed, wind direction and how much the chairs are swinging.
"Our lift maintenance staff makes case-by-case determinations based on these criteria."
That's the same policy at Mt. Abram in Greenwood and Shawnee Peak in Bridgton, officials there said. Austin added that crosswinds are more likely to cause problems than wind blowing straight up or down the mountain.
Sugarloaf faces north-northeast and, according to the weather service, the wind Tuesday blew from the northwest, across the Spillway East lift.
Penniman said the Borvig ski lift has been replaced by newer models at most large ski areas.
But older lifts, like older airplanes, are safe if well maintained and operated within safety limits, he said.
-- Staff Writer Emma Bouthilette contributed to this report.
Staff Writer Jonathan Hemmerdinger can be contacted at 791-6316 or at: firstname.lastname@example.org